Other Engine Info: BIN 5 emission. Emissions Certification Test Group: DADXJ02.03UA
Other Restraint System Info:
Plant City: Wolfsburg
Plant Country: Germany
Seat Belts All: Manual
TPMS: Indirect
Transmission Style: Manual/Standard
Vehicle Type: PASSENGER CAR
Model year
COMPONENT
Complaint
2007
ELECTRICAL SYSTEM
MY 2007 VW GTI DSG HAS TRANSMISSION SAFETY PROBLEMS THAT HAVE CAUSED ME TO NEARLY GET HIT NUMEROUS TIMES. THE PROBLEMS BEGAN WHEN THE CAR WAS LESS THAN 4 MONTHS OLD. WITHOUT WARNING THE CAR SLIPS OUT OF GEAR, LAGS, THEN GRABS GEAR AGAIN AND HAS TO RE-ACCELERATE CAUSING LOSS OF CONTROL OF VEHICLE SPEED. THIS HAS HAPPENED IN TRAFFIC AT SPEEDS OF 65 AS WELL AS IN CITY 30-45 MPH. THIS HAS HAPPENED WHEN PULLING OUT ONTO A BUSY TURNPIKE AND SUDDENLY HAVING THE CAR HAVE NO ACCELERATION POWER ALMOST CAUSING ME TO GET HIT BY ONCOMING TRAFFIC. WHEN GOING AT HIGHWAY SPEEDS IT HAS HAPPENED WITH NO WARNING AND SUDDENLY THE CAR DECELERATES AND THERE IS A SEVERAL SECOND LAG BEFORE IT GRABS AND DECIDES TO GO AGAIN. THIS CAN HAPPEN SEVERAL TIMES CONSECUTIVELY WHICH IS A VERY SERIOUS SAFETY ISSUE. I HAVE HAD THE CAR INTO THE DEALER AT LEAST 8-10 TIMES AND EVERYTIME THEY TELL ME IT IS FIXED AND THEN I PULL OUT AND IT SLIPS OUT OF GEAR AGAIN. THEY HAVE REPLACED THE MECATRONIC UNIT, REFLASHED THE ECM, ADDED IN A MISSING LAUNCH CONTROL PROGRAM AND REPLACED INTAKE FLAP MOTOR. THESE PROBLEM HAVE TAKEN ALL MY FAITH OUT OF THE VEHICLE. EVERYTIME I DRIVE I AM AFRAID. YOU DON'T KNOW WHEN IT WILL SLIP OUT OF GEAR AND LOSE POWER. I HEAR A LOUD THUNK FROM THE ENGINE AND IT FEELS LIKE THE CAR HAS BEEN HIT FROM UNDER THE HOOD. I HAVE TO CONTINUE THIS ON ANOTHER COMPLAINT FORM B/C OF LENGTH, PLS. SEE PAGE 2 OF CHRIS DUNN 2007 VW GTI *TR
2013
FUEL/PROPULSION SYSTEM
TOOK CAR FOR FIRST DRIVE. AFTER TRAVELING 145 MILES INTO THIS TRIP WHEN TROUBLE STARTED. AMBIENT TEMP WAS 101F. DRIVE TIME WAS JUST OVER 2.5 HOURS. GAS TANK WAS SLIGHTLY OVER HALF EMPTY. CAR STALLED TAKING OFF FROM STOP. ENGINE RUNNING BUT CAR WOULD NOT ACCELERATE. ENGINE THEN STOPPED. CRANKED OVER (STARTED) AND WENT ABOUT 2 BLOCKS. CAR STALLED AGAIN. THIS TIME IT WAS DIFFICULT TO GET STARTED AGAIN. HAD TO CRANK IT 3-4 TIMES. STARTED THEN STALLED. ENGINE MALFUNCTION LIGHT CAME ON. EVENTUALLY STARTED. WHILE DRIVING ON HIGHWAY AT 55MPH ENGINE TURNED OFF WITHOUT WARNING. I POINTED CAR TO THE SHOULDER AND BRAKED TO A STOP. TWO MORE STOP LIGHT INCIDENTS WHERE CAR STALLED AND QUIT RUNNING AT AND IN INTERSECTIONS. PULLED OVER AND CALLED DEALER. TALKED TO SERVICE CONSULTANT. DISCUSSED OPTIONS. ENGINE MALFUNCTION LIGHT ON ALL THE TIME. EVEN THOUGH ROADSIDE ASSISTANCE WAS OFFERED, SERVICE CONSULTANT STATED THAT SINCE THE ENGINE LIGHT WAS STEADY AMBER IT SHOULD BE OK TO DRIVE IF I WAS COMFORTABLE DOING IT. I DETERMINED MY BEST OPTION WAS TO DRIVE IT BACK TO TUCSON. WAITING FOR ROADSIDE ASSISTANCE ON HWY 191 BETWEEN SAFFORD AND WILLCOX IN 100F+ SUNSHINE WOULD HAVE BEEN UNACCEPTABLE, IF NOT MORE DANGEROUS THAN DRIVING THE CAR - BECAUSE OF THE REMOTE LOCATION AND THE EXTREME HEAT. MADE IT BACK TO TUCSON. DROVE STRAIGHT TO SERVICE AND DROPPED THE CAR OFF. TOTAL MILEAGE ON CAR 353 MILES. NOTE THAT I HAD NOT ADDED ANY GAS TO THE VEHICLE, AND WAS STILL USING THE GAS PROVIDED BY DEALER UPON DELIVERY. (I MENTION THIS BECAUSE A TECH ASKED IF DIESEL FUEL WAS PUT IN THE TANK INSTEAD OF GAS. NO!) DEALER SERVICE CONFIRMED FUEL PUMP NOT WORKING PROPERLY AND REPLICATED PROBLEM. NOTED FUEL PUMP EXTREMELY HOT AND DISCOVERED ASSOCIATED ELECTRICAL DAMAGE TO FUEL CONTROL MODULE WITH STRONG POTENTIAL FOR FIRE. IN MY OPINION, THIS IS A CRITICAL SAFETY PROBLEM AND SHOULD BE INVESTIGATED. *TR