SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE
WHILE APPLYING THE BRAKES INSIDE OF THE PARKING GARAGE THE PEDAL WENT TO THE FLOOR. THE DRIVER SKIDDED INTO ANOTHER VEHICLE. THIS PROBLEM HAS HAPPENED THREE TIMES. THE DRIVER TOOK VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC INFORMED DETERMINED THAT THE PROBLEM COULD NOT BE DUPLICATED. *AK THE DRIVEWAY WAS ON AN UPHILL INCLINE AND WAS COVERED IN SNOW. THE BRAKE PEDAL VIBRATED AND THE VEHICLE LURCHED FORWARD INSTEAD OF STOPPING. THIS WAS AN INTERMITTENT PROBLEM. *SC THE CONSUMER STATED A RECALL WAS ISSUED ON THE ABS. *JB
2013
FUEL/PROPULSION SYSTEM
WE PURCHASED THE 2013 HYUNDAI SANTA FE SPORT (2WD) ON 2/23/13. WHEN I ATTEMPTED TO FILL UP THE GAS TANK FOR THE FIRST TIME, THE GAS PUMP CONTINUOUSLY SHUT OFF AUTOMATICALLY AS IF THE TANK WAS FULL. IT TOOK APPROXIMATELY 15-20 MINUTES TO FILL UP 3/4 OF THE TANK. I INITIALLY THOUGHT IT WAS THE GAS PUMP THAT WAS BAD. ABOUT A WEEK LATER, WHEN I ATTEMPTED TO FILL UP AGAIN, THE SAME PROBLEM OCCURRED ON A DIFFERENT PUMP. I TRIED A COUPLE OF DIFFERENT GAS STATIONS, AND THE PROBLEM CONTINUED. I TOOK THE VEHICLE IN TO A HYUNDAI DEALERSHIP FOR A CHECK UP. AFTER A PRELIMINARY CHECK, THE DEALER ADVISED THAT THERE WAS NO ERROR CODE. HOWEVER, IN ORDER FOR THEM TO REMOVE THE TANK AND CHECK THE ENTIRE ASSEMBLY, THE GAS TANK WAS TOO FULL, SO I NEEDED TO DRIVE IT AROUND AND USE UP SOME GAS UNTIL IT WAS LESS THAN 1/2 TANK FULL. SO AFTER A FEW DAYS, I TOOK IT IN AGAIN. AFTER A FEW DAYS, THEY ADVISED THAT THE AFTER REMOVING THE TANK, THEY OBSERVED THE FUEL TANK NECK END HAD BEEN MELTED. THEY WERE NOT SURE WHAT THE CAUSE WAS. SO THEY REPLACED THE FUEL TANK, AND FILLED THE GAS TANK WITHOUT ANY ISSUES. WE JUST GOT THE CAR BACK, SO WE'LL SEE IT THE PROBLEM HAS BEEN FIXED, OR IF IT'LL BE A RECURRING PROBLEM. WE THOUGHT IT WAS VERY ODD THAT A BRAND NEW CAR WOULD HAVE THIS PROBLEM, AND WE'RE MORE CONCERNED WHAT CAUSED IT TO "MELT". IF THERE IS A MAJOR HEAT ISSUE THAT WOULD CAUSE SOMETHING TO MELT NEAR THE GAS TANK, THIS IS A VERY SERIOUS CONCERN. THE DEALER ADVISED US THAT AN ENGINEER FROM HYUNDAI CAME OUT TO INSPECT IT UPON LEARNING ABOUT THE PROBLEM. WE'VE FOUND NUMEROUS SIMILAR COMPLAINT ONLINE, AND NOT ONLY WITH THE SANTA FE BUT WITH MANY OTHER HYUNDAI MODELS. IN FACT, THE 2012 HYUNDAI SONATA RENTAL THEY PROVIDED US WITH HAD A SIMILAR PROBLEM WHERE IT WOULD SHUT OFF EVERY 2 1/2 GALLONS. THE DEALER FIXED THE PROBLEM FOR NOW, BUT WE'LL HAVE TO MONITOR IT. *TR