DT: THE CONTACT STATES THIS IS THE FOURTH FUEL PUMP THAT HE PUT ON THE VEHICLE. THE DEALERSHIP REPAIRED TWO OF THE FUEL PUMPS, AND THE CONTACT REPAIRED THE THIRD ONE HIMSELF. AT THIS POINT, THE VEHICLE WILL NOT START. HE CONTACTED MANUFACTURER ,AND THEY OFFERED NO FREE REMEDY.*AK
1992
SERVICE BRAKES, HYDRAULIC:ANTILOCK
I RECEIVED A RECALL NOTICE FROM GENERAL MOTORS DURING THE SUMMER OF 2000. THE RECALL NOTICE WAS CREATED BY THE NATION TRAFFIC AND MOTOR VEHICLE ACT AND WAS TITLED CAMPAIGN #G99041-S. I SCEDULED MY VEHICLE FOR THE UPGRADE AND HAD THIS SERVICE PERFOMED ON 09/20/00. APPROXIMATELY TWO WEEKS AFTER THE UPGRADE THE VEHICLE WAS PLACED IN FOUR WHEEL DRIVE (PUSH BUTTON TYPE) AND WOULD NOT RELEASE AFTER SEVERAL ATTEMPTS. I REVIEWED THE VEHICLE MANUAL AND WALKED THROUGH THE PROCESS OF RELEASING THE 4WD IF IT BECAME LOCKED UP AND FORTUNATELY IT WORKED AND RELEASED. I MADE ANOTHER APPOINTMENT WITH THE ORIGINAL DEALER. HIS TECHNICIANS REVIEWED THE VEHICLE ON 10/04 AND SAID THAT THEY HAD PLUGGED IN A VACUMN WRONG AND NOW EVERYTHING WOULD BE OK. APPROXIMATELY TWO MONTHS LATER I WAS DRIVING THE VEHICLE AND HAD THE FIRST OPPORTUNITY TO ENGANE THE ABS UNIT. IT ENGAGED AND WORKED AS IT HAD FOUR ABOUT EIGHT YEARS. THE FOLLOWING DAY BOTH THE ABS AND BRAKE DASHBOARD WARNING LIGHTS ILLUMINATED AND STAYED ILLUMINATED. BECAUSE OF TH EBRAKE LIGHT BEING ILLUMINATED AND THE FACT THAT THE VEHICLE HAD THE ORIGINAL BACK BRAKE SHOES I THOUGHT THAT I CHANGED THE BACK SHOES THAT LIGHT ISSUE MIGHT GO AWAY. AFTER CHANGING THE BACK BRAKE SHOES, INSTALLING SPRING KITS, AND TURNING THE DRUMS, I REASSEMBLED, ADJUSTED THE SHOES AND "TRIED THE PEDAL" IN MY GARAGE. BOTH THE STANDARD BRAKE PEDAL AND THE EMERGENY BRAKE PEDALS RESPONDED CLOSE TO THE TOP OF THEIR POSITIONS. AT THIS TIME I STARTED THE VEHICLE AND THE BRAKE PEDAL IMMEDIATLY "FELL" TO THE FLOOR. THE PEDAL PUMPED UP BUT AFTER SEVERAL SECONDS AGAIN FELL TO THE FLOOR. I PURCHASED A NEW MASTER CYINDER FROM NAPA AND INSTALLED IT. ONLY AFTER A COMPLETE SYSTEM BEEDING DID I REGAIN ANY BRAKE PEDAL. BOTH THE ABS AND BRAKE LIGHT STAYED "ON". BACK TO THE DEALER, REPORTED DEFECTIVE ABS ($1400.00) I FEEL THE ORIGINAL RECALL AND DEALER WORK CREATED BRAKE FAILURE.*AK