CABIN BRAKE ASSEMBLY BRACKET BENDS WHEN APPLYING THE BRAKES DURING (BUT NOT LIMITED TO) EMERGENCY STOPPING. THIS MOVEMENT CAUSES THE EDGE OF THE BRAKE PIVOT BOLT TO HANG ON THE UPPER BRAKE ASSEMBLY, LOCKING THE BRAKE PEDAL TO THE FLOOR AND PREVENTING THE BRAKE FROM DISENGAGING. ADDITIONALLY, WHEN THIS DOES OCCUR, LOSS OF ADEQUATE BRAKE LEVERAGE AND/OR SUDDEN CHANGE IN PROXIMITY OF THE BRAKE PEDAL TO THE FLOOR MAY PREVENT THE DRIVER FROM APPLYING THE BRAKES TO THEIR INTENDED CAPACITY. THIS IS OF PARTICULAR CONCERN DURING AN ACCIDENT AVOIDANCE SITUATION WHEN ADEQUATE FOOT PRESSURE FAILS TO ENGAGE THE VEHICLE'S ABS. THIS DIRECTLY LEADS TO INCREASED DANGER OF INJURY/FATALITY TO DRIVERS, PASSENGERS, OCCUPANTS OF OTHER VEHICLES, AND PEDESTRIANS. TOOK VEHICLE TO DEALER TO ADDRESS THIS DEFECT. DEALER REFUSED TO REMEDY THIS SAFETY DEFECT AT NO COST TO CUSTOMER. *TR
2006
ENGINE AND ENGINE COOLING
MY SON WAS DRIVING OUR 2006 TOYOTA HIGHLANDER. HE DROVE APPROX 2 MILES FROM OUR HOUSE AT AN AVERAGE SPEED OF 35 MPH WHEN THE TEMPERATURE GAUGE SUDDENLY WENT PAST THE RED LINE. HE DROVE OUR CAR APPROX 2 MILES BACK TO OUR HOUSE. WE THEN HAD IT TOWED TO SAVANNAH TOYOTA WHERE THEY CHECKED THE ENGINE AND FOUND THE HEAD WARPED AND THE BOLTS STRIPPED . I WENT TO SAVANNAH TOYOTA AND TOLD THEM THAT I HAD JUST HAD THE CAR THERE FOR AN OIL CHANGE A MONTH PRIOR. AT THE TIME OF OIL CHANGE, SERVICE WRITER NOTED UNDER THE HOOD THAT HE THOUGHT THAT MAYBE THE WATER PUMP MAY BE LEAKING AS THERE WAS FLUID ON THE UPPER PART OF HOOD. THERE WAS NO NOTIFICATION OF ANY PROBLEM WITH THE WATER PUMP. A MONTH LATER, THE ABOVE OVERHEAT CONDITION OCCURRED. WHEN WE WERE INFORMED THAT THE ENGINE WAS BURNED UP AND THE ENGINE NEEDED TO BE REPLACED AT A COST OF 5000.00. WE HAD THE VEHICLE TOWED TO OUR REGULAR MECHANIC AND WAS TOLD THAT THERE WAS NOTHING WRONG WITH THE ENGINE BLOCK, JUST THE HEAD NEEDS TO BE REPLACED AT A COST OF APPROX. 2200.00.SAVANNAH TOYOTA DID CHARGE US $600 TO CHECK WHAT CAUSED THE PROBLEM AND IF THE ENGINE COULD BE SAVED. WE WERE TOLD THAT THE ENGINE BLOCK BOLTS WERE STRIPPED AND COULD NOT BE RE-INSTALLED. AFTER DIS-ASSEMBLING THE ENGINE TO EVALUATE THE PROBLEM THEY DID NOT EVEN REASSEMBLE OUR ENGINE. THE CAR WAS NO LONGER UNDER WARRANTY AT 70,000 MILES. WE HAVE NOT YET REPAIRED THE PROBLEM CAR HAS BEEN PARKED SINCE 3-20-11 TO DATE 11-22-2011 . *TR
