I OWN A 2008 SATURN OUTLOOK, WHICH I PURCHASED NEW IN AUGUST OF 2007. IN FEBRUARY OF 2010, I NOTICED MY RIGHT LOW-BEAM HEADLIGHT/DAYTIME RUNNING LIGHT WAS OUT. I CONTACTED MY LOCAL SATURN SERVICE CENTER AND WAS TOLD THAT THERE HAD BEEN "SOME PROBLEMS WITH THE WIRING HARNESS" AND I SHOULD BRING IT IN FOR A REPLACEMENT HARNESS, SINCE IT WAS STILL UNDER WARRANTY, WHICH I DID. IN APRIL 2010, THE LEFT LOW BEAM HEADLIGHT/DAYTIME RUNNING LIGHT WENT OUT. I AGAIN CONTACTED SATURN AND ASKED IF, ASSUMING THIS WAS THE SAME PROBLEM, IT WOULD BE COVERED BY WARRANTY, SINCE THEY HAD ALREADY ACKNOWLEDGED THAT A PROBLEM EXISTED WITH THIS HARNESS (THE VEHICLE WAS ABOUT 2,000 MILES OVER WARRANTY BY THIS TIME). I WAS TOLD THAT, SINCE THERE HAD BEEN NO RECALL, IT WOULD NOT BE A WARRANTY ITEM, AND THAT I WOULD HAVE TO PAY FOR THE REPAIRS MYSELF. SINCE THE SATURN DEALER IS ABOUT 50 MILES AWAY, AND IT WAS NOT GOING TO BE COVERED BY WARRANTY, I OPTED TO HAVE IT REPAIRED AT A SHOP MUCH CLOSER TO HOME. AFTER DETERMINING THAT THE BULB WAS FUNCTIONAL, THEY ORDERED A NEW WIRING HARNESS, AND INSTALLED IT IN LESS THAN AN HOUR (TO THE TUNE OF $171.44). I ASKED TO SEE THE OLD HARNESS, AND UPON INSPECTION, I OBSERVED THAT THE HOUSING AROUND ONE OF THE CONNECTION POINTS WAS CLEARLY BURNT AND MELTED. I HAVE HEARD OF NUMEROUS OTHER REPORTS OF THIS FAILURE, MUCH LIKE THE RECALLED WIRING HARNESS FOR THE HEATED WINDSHIELD WIPERS. THIS HARNESS DEFECT CLEARLY IS A SAFETY ISSUE AND SHOULD BE RECALLED. *TR
2009
ELECTRICAL SYSTEM
THE HEADLAMP ON THE RIGHT SIDE WENT OUT IN JULY 2011 AND WE HAD IT REPLACED AT A GM DEALERSHIP. SEPTEMBER 20TH, 2011 ROLLS AROUND AND THE SAME HEADLAMP IS OUT AGAIN! FUNNY THING, AS I'M DRIVING AROUND TOWN I'M NOTICING THE SAME PROBLEM (RIGHT SIDE EVEN) ON OTHER GM VEHICLES OF THE SAME BODY STYLE. *TR